MF01 – 3.31 Installation, Operation & Maintenance Instructions 1100°C Chamber Furnaces ELF models This manual is for the guidance of op
ELF (B) 10 MF01 3.31 6.0 FAULT ANALYSIS A. Furnace Does Not Heat Up 1. The HEAT light is ON The heating element has failed Check also
ELF (B) MF01 3.31 11 7.0 ELF 6L & 14L CIRCUIT DIAGRAM AND FUSES 7.1 200-240V models NOTE – models before mid-2002: two door switches were
ELF (B) 12 MF01 3.31 8.1 200-240V models 104 - 120V models Instrument Switch coil temperature controller overte
ELF (B) MF01 3.31 13 Fuses 8.2 Fuses are marked on the circuit diagram (above) with type codes, e.g. F1, F2. A list of the correct fuses is tabl
ELF (B) 14 MF01 3.31 9.0 SPECIFICATIONS Carbolite reserves the right to change specifications without notice. 9.1 Models Covered by this Manu
ELF (B) MF01 3.31 15
MF01 – 3.31 Carbolite, Parsons Lane, Hope, Hope Valley, S33 6RB, England. Telephone: +44 (0)1433 620011 Fa
ELF (B) 2 MF01 3.31 1.0 INTRODUCTION 1.1 Models Covered by this Manual This manual covers the Carbolite furnace models ELF 11/6B, ELF 11/14B
ELF (B) MF01 3.31 3 2.0 INSTALLATION 2.1 Unpacking & Handling When unpacking or handling the furnace always lift it by its base. Never lif
ELF (B) 4 MF01 3.31 Amps: the actual supply must be capable of supplying the required amps. It should be fused at the next available fuse size
ELF (B) MF01 3.31 5 Light weight ceramic fibre insulation can easily be marked by accidental contact. Some fine cracks may be visible on the surfa
ELF (B) 6 MF01 3.31 4.0 MAINTENANCE 4.1 General Maintenance Preventive rather than reactive maintenance is to be preferred. The type and freque
ELF (B) MF01 3.31 7 5.0 REPAIRS & REPLACEMENTS 5.1 Safety Warning – Disconnection from Supply Always ensure that the furnace is disconnect
ELF (B) 8 MF01 3.31 5.5 Thermocouple Replacement Disconnect the furnace from the supply, and remove the furnace back panel. Make a note of t
ELF (B) MF01 3.31 9 Door Plug Replacement The “door plug” is also known as the “door insulation piece”. Lower the furnace door to the fully ope
Comentários a estes Manuais